Suzuki DF 50 Service Manual

2-3 PERIODIC MAINTENANCE
ENGINE OIL CHANGE / ENGINE OIL FILTER
REPLACEMENT
ENGINE OIL
Change initially after 20 hours (1 month) and every
100 hours (6 months) thereafter.
ENGINE OIL FILTER
Replace initially after 20 hours (1 month) and every
200 hours (12 months) thereafter.
NOTE:
• Engine oil should be changed while the engine is warm.
• When replacing the engine oil filter, change engine oil at the
same time.
1. Place the outboard motor upright on a level surface.
2. Remove the oil filler cap.
3. Place a container under the engine oil drain plug.
4. Remove the engine oil drain plug and gasket to drain en-
gine oil.
z
o
5. ENGINE OIL FILTER REPLACEMENT
NOTE:
For engine oil change only, go to step 6.
To replace the engine oil filter :
(1) Remove the PORT side lower cover. (See page 7-1)
(2) Using oil filter wrench, loosen the oil filter.
09915-47340 : Oil filter wrench
NOTE:
Before fitting new oil filter, be sure to oil O-ring.
1Oil filler cap
1
1Oil drain plug 2Gasket
1
2

Suzuki DF 50 Specifications

General

Engine Type	4-Stroke
Cylinders	3
Displacement	941 cc
Starting System	Electric
Steering	Remote
Engine Type Detail	DOHC 12-Valve
Maximum Output	50 HP
Ignition System	Digital CDI
Alternator	12V 19A
Gear Ratio	2.27:1
Exhaust	Through Prop Hub Exhaust
Trim Method	Power Trim and Tilt
Max Power	50 HP
Alternator Output	12V 19A
Fuel Delivery System	Sequential Multi Point Electronic Fuel Injection
Full Throttle Operating Range	5, 300 - 6, 300 rpm
Engine Oil Capacity	2.7 L
Full Throttle RPM Range	5300 - 6300 RPM
Oil Capacity	2.7 L
Bore x Stroke	72.5 x 76.0 mm (2.85 x 2.99 in.)