Name: Zontes ZT310-V
Brand: Zontes
Rating: 4 (1 reviews)

To Next Page

ZT310-V (EURO IV/V)

Service manual

2020/11/27

Contents2
Table of Contents4
Frame Component8
Flasher and Dump Switch8
Seat Lock8
Main Harness8
Horn9
Flameout Switch9
Rectifier9
Ignition Coil9
Assemble11
Disassembly11
Checking the Cushion Loop12
Replacing the Engine Oil Filter Screen12
Realease the Frame Tube Enging Oil12
Sider Support12
PKE Controller13
PKE Bracket13
Fuse13
Charging13
Anti-Scald Left Muffler Plate14
Engine Left Rear Cover14
Engine Right Trim Cover Assembly14
Front Footrest Bracket,Wind Fairing Bracket15
Disassemble the Engine15
Air Filter16
Throttle Assembly16
Throttle Valve Assembly17
Carbon Tank18
Carbon Tank Electromagnetic Valve18
Side Cover19
Maintenance19
Back Inner Mud Board20
Let Rear Shock Absorption20
Left Side21
Right Side21
Electric Device Box22
Air Filter Bottom Case22
Air Filter Element23
Left Rear Shock Absorption24
Rear Auxiliary Mud Board Assembly28
Retaining Plate29
Rear Auxiliary Mud Plate Iron Bracket29
Iron Support29
Turn Signal Subassembly30
Back Reflector, License Plate Cushion Rubber30
Fender Sub-Assembly30
Steering Lights, Fender Sub-Assemblies30
Rear Turning Light31
Rear Inner Mudguard32
Rear Shock Absorber33
Adjust the Rear Absorber33
Rear Wheel Assembly34
Sprocket Bracket Assembly34
Disc Brake Plate, ABS Gear Ring35
EURO IV:tire and Rim Assembly35
Rear Fork Assembly36
Rear Fork Rear-Resistant Block36
Disassemble Disc Brake Arrester37
Change Rear Disc Brake Arrester37
Add Disc Brake Liquid38
Adjust the Height of Gear Shift Rod39
Adjust the Height of Brake Pedal39
Front Pedal Bracket40
Move Front Left Pedal Foeward42
Front Right Pedal Bracket Component43
Front Right Pedal after Sale Parts44
Gear Shift Rod Assembly45
Front Left Pedal Bracket Component46
Front Left Pedal Component46
Front Left Pedal after Sale Parts47
Rear Left Pedal Bracket Assembly48
Rear Right Pedal Bracket Assembly49
Rear Right Pedal49
Drain off the Engine Oil51
Engine Decorative Cover Assembly52
Change Engine Oil Filter52
Add Coolant53
Cooling Liquid53
- Radiator Decorative Cover Assembly54
- Sub Water Tank Assembly56
- Sub Water Tank Bracket56
- Chassis Connected Oil Tube57
- Engine Oil Outlet Tube57
- Engine Decorative Cover Assembly58
- Drain the Cooling Liquid58
- Main Water Tank Assembly59
- Main Tank Assembly60
- Clutch Line61
Front Fork Component61
Throttle/Clutch Cable Clearance Adjustment61
Decorative Hood over Headlamp62
Light Height Adjustment62
- Remove the Cluch Line63
- Install the Clutch Line63
- Disassemble the Throttle Line64
- Install the Throttle Line64
- Check Steering Device65
- Steering Bearing65
- Front Disc Brake Main Pump66
Add Brake Fluid, Rocker Adjustment66
- Replace the Front Brake Pad67
- Front Brake Caliper Mounting Plate67
- Tire and Wheel Assembly68
- Brake Disc, ABS Ring Gear68
- Tire and Rim Assembly68
- Tire Pressure Wireless Built-In Sensor68
Front Wheel Component68
Front Disc Brake Caliper69
Front Mud Board & Wheel Speed Sensor Component69
Turn Signal Assembly70
Headlights Assembly 170
- Headlight Assembly71
- Headlight Bracket72
- Storage Box72
- Rearview Mirror73
- Right Handlebar to Put Rubber Sleeve, Balance Block73
- Right Handlebar Half Cover73
- Front Brake Switch Replacement73
- Left Rear View Mirror, Left Switch, Rocker Arm74
- Replace the Left Hand Rocker Arm and Clutch Switch74
- Directional Components75
- Instrumentation Components75
- Faucet Lock76
- Uplink Board Assembly76
- Reflecting Film76
- Front Left and Right Shock Absorption76
- Uplink Plate and Spacer Assembly77
- Hydraulic Control Unit Cover78
- Hydraulic Control Unit78
- Brake Fluid78
- Hydraulic Control Unit Bracket78
- Front Disc Brake Tubing Bracket80
- Disc Brake Pipe Clamp82
- Rear Disc Brake Caliper82
- RC-HU Oil Pipe82
- Fuel Tank Assembly83
- Tank Middle Cover Assembly84
- Fuel Tank Lock84
- Fuel Tank Cover Assembly84
- Fuel Tank Cushion Rubber86
- Fuel Pump86
- Fuel Tank Cap86
- Fuel Tank Middle Decorative Cover87
- Fuel Tank Decoration Cover Assembly89
- Bumper Decorative Ball92
- Bumper Assembly93
- Right Bumper Assembly94
- Left Bumper Assembly94
- Left Engine Decorative Cover Assembly95
- Electrical Device Box Cover96
- Battery96
- Battery Bottom Cover97
- Battery Holder97
- Backrest Assembly Componen98
- Without Backrest98
- The Tail Light Plug99
- Buzzer99
- PKE Antenna99
- Rear Cover Trim Cover100
- Rear Aluminum Alloy Bracket101
- Rear Light102
- Electrical Device Box Component103
- Fuses103
- Remove Seat Cushion105
- Assembly Cushion105
- Cushion Rubber and Belt, Purchased Separately105
- Muffler Assembly106
- Front-Left Pedal Bracket Assembly107
- The Front of the Muffler107
- Oxygen Sensor108
- Decorative Cover109
- Lower Shroud Assembly110
- Lower Shroud Bracket110
- Shroud Left Part111
- Shroud Right Part111
- Shroud Middle Part111

Brand	Zontes
Model	ZT310-V
Category	Motorcycle
Language	English

Zontes ZT310-V User Manual

Table of Contents

Questions and Answers:

Zontes ZT310-V Specifications

Related product manuals