Yamaha Tracer MT09TRAH 2017 User Manual

PERIODIC MAINTENANCE
3-28
6. Drain:
• Coolant
(from the engine and radiator)
7. Install:
• Water pump drain bolt
• Copper washer
8. Install:
• Collars
• Coolant reservoir
• Coolant reservoir cover
• Coolant reservoir bolt
9. Fill:
• Cooling system
(with the specified amount of the recom-
mended coolant)
Handling notes for coolant
Coolant is potentially harmful and should be
handled with special care.
WARNING
EWA13040
• If coolant splashes in your eyes, thorough-
ly wash them with water and consult a doc-
tor.
• If coolant splashes on your clothes, quickly
wash it away with water and then with soap
and water.
• If coolant is swallowed, induce vomiting
and get immediate medical attention.
NOTICE
ECA21291
• Adding water instead of coolant dilutes the
antifreeze concentration of the coolant. If
water is used instead of coolant; check,
and if necessary, correct the antifreeze
concentration of the coolant.
• Use only distilled water. However, if dis-
tilled water is not available, soft water may
be used.
• If coolant comes into contact with painted
surfaces, immediately wash them with wa-
ter.
• Do not mix different types of antifreeze.
10.Install:
• Radiator cap stopper
• Radiator cap
• Radiator cap bolt
• Front side panel (right)
Refer to “GENERAL CHASSIS (2)” on page
4-6.
11.Fill:
• Coolant reservoir
(with the recommended coolant to the maxi-
mum level mark “a”)
12.Install:
• Coolant reservoir cap
13.Start the engine, warm it up for several min-
utes, and then turn it off.
14.Check:
• Coolant level
Refer to “CHECKING THE COOLANT LEV-
EL” on page 3-26.
TIP
Before checking the coolant level, wait a few
minutes until the coolant has settled.
EAS30814
CHECKING THE FRONT BRAKE LIGHT
SWITCH
Refer to “ELECTRICAL COMPONENTS” on
page 8-149.
Water pump drain bolt
10 N·m (1.0 kgf·m, 7.2 lb·ft)
Coolant reservoir bolt (M5)
0.5 N·m (0.05 kgf·m, 0.36 lb·ft)
Coolant reservoir bolt (M6)
9 N·m (0.9 kgf·m, 6.5 lb·ft)
Recommended antifreeze
High-quality ethylene glycol anti-
freeze containing corrosion
inhibitors for aluminum engines
Mixing ratio
1:1 (antifreeze: water)
Radiator (including all routes)
1.93 L (2.04 US qt, 1.70 Imp.qt)
Coolant reservoir (up to the maxi-
mum level mark)
0.25 L (0.26 US qt, 0.22 Imp.qt)
New
T
R
.
.
T
R
.
.
Radiator cap bolt
5 N·m (0.5 kgf·m, 3.6 lb·ft)
T
R
.
.
a

Yamaha Tracer MT09TRAH 2017 Specifications

General

Brand	Yamaha
Model	Tracer MT09TRAH 2017
Category	Motorcycle
Language	English