Toyota Orderpicker Model
7BPUE
15
Service Manual Section
4.
Planned Maintenance
Interval
1
Interval
1
Battery
I
Check cleanliness and exterior condition.
Check the charge.
Check the connector. Make sure all powered functions are shut
down when disconnected.
1
Gates must be properly installed and securely locked in place.
I
Page 7
-
33
11
Check the
"
free play
"
of the battery. Make sure it has no more
than
1/2"
(13
mm) of movement.
1
Check the speed and directional controls.
Page 7
-
33
General Operation
1
Check the steering operation.
Check that the horn operates when you press the horn button.
(Battery must be connected.)
1
Check the lifting and lowering functions.
1
Check the operation of the emergency power off switch.
Check that the control handle returns to the neutral position
when released.
Brake
Hydraulic System
I
Check for oil leaks.
Note any unusual noise during operation, and report it to the
supervisor or maintenance personnel.
Verify the drive motor does not run while the brake is applied.
Wheels Check the condition of the drive wheel and load wheels. Remove
any steel chips and foreign material to prevent damage to the
wheels.
Check for gouging and chunking of the surface. If damaged,
report to your supervisor and maintenance personnel.
Safety Belt and
Tether
Deadman Pedal
Inspect. Replace any components that show damage or excessive
wear.
The deadman pedal must operate smoothly with no binding.
Disables travel,
lift/lower functions, and stops the truck when the
pedal is released.
00700
-
CL222
-
05,
1
5
March
2005
Page 7
-
27
Fire Extinguisher
Check charge. Replace if charge is low.
To Next Page
Loading...
Need help?
General
