Yamaha Raptor 700R 2009 Service Manual

LIGHTING SYSTEM
8-17
EAS27260
TROUBLESHOOTING
Any of the following fail to light: headlight or taillight.
T
IP
• Before troubleshooting, remove the following part(s):
1. Seat
2. Fuel tank top panel
3. Front panel
4. Front fender
NG →
OK ↓
NG →
OK ↓
NG →
OK ↓
NG →
OK ↓
NG →
OK ↓
NG →
OK ↓
NG →
OK ↓
1. Check the condition of each bulb
and bulb socket.
Refer to “CHECKING THE BULBS
AND BULB SOCKETS” on page
8-60.
Replace the bulb(s) and bulb socket(s).
2. Check the fuses.
(Main and headlight)
Refer to “CHECKING THE FUS-
ES” on page 8-61.
Replace the fuse(s).
3. Check the battery.
Refer to “CHECKING AND
CHARGING THE BATTERY” on
page 8-62.
• Clean the battery terminals.
• Recharge or replace the battery.
4. Check the main switch.
Refer to “CHECKING THE
SWITCHES” on page 8-57.
Replace the main switch.
5. Check the light switch.
Refer to “CHECKING THE
SWITCHES” on page 8-57.
The light switch is faulty. Replace the han-
dlebar switch.
6. Check the headlight relay.
Refer to “CHECKING THE RE-
LAYS” on page 8-65.
Replace the headlight relay.
7. Check the entire lighting system
wiring.
Refer to “CIRCUIT DIAGRAM” on
page 8-15.
Properly connect or repair the lighting sys-
tem wiring.
Replace the tail/brake light assembly.

Yamaha Raptor 700R 2009 Specifications

General

Brand	Yamaha
Model	Raptor 700R 2009
Category	Offroad Vehicle
Language	English