Honda NC700 2012 User Manual

25-2
dummytext
INDEX
HEADLIGHT································································· 22-5
HEADLIGHT AIM·························································· 3-25
HEADLIGHT COVER (NC700S/SA/SD) ······················ 2-27
HEADLIGHT/FRONT CENTER COWL
(NC700X/XA/XD)·························································· 2-26
HEADLIGHT/HEADLIGHT STAY (NC700S/SA/SD) ···· 2-27
HIGH COOLANT TEMPERATURE INDICATOR/ECT
SENSOR ···································································· 22-18
HISS INDICATOR ······················································ 23-10
HORN········································································· 22-29
I
IACV············································································· 7-22
IGNITION COIL···························································· 5-10
IGNITION SWITCH ···················································· 22-24
IGNITION SYSTEM INSPECTION································· 5-6
IGNITION TIMING·························································· 5-9
IMMOBILIZER RECEIVER········································· 23-12
INJECTOR···································································· 7-20
INNER UPPER COVER (NC700X/XA/XD) ·················· 2-25
K
KEY REGISTRATION PROCEDURES························ 23-3
L
LEFT REAR COVER···················································· 2-29
LOWER COWL····························································· 2-28
LUBRICATION & SEAL POINTS ································· 1-23
LUBRICATION SYSTEM DIAGRAM······························ 9-2
LUGGAGE BOX··························································· 2-19
LUGGAGE BOX LID····················································· 2-17
LUGGAGE BOX LID/HINGE ASSEMBLY···················· 2-19
M
MAIN JOURNAL BEARING·········································· 15-8
MAINSHAFT SENSOR············································· 12-115
MAINTENANCE SCHEDULE········································· 3-3
METER STAY (NC700X/XA/XD)·································· 2-24
MIL CIRCUIT TROUBLESHOOTING··························· 4-63
MIL TROUBLESHOOTING ·········································· 4-43
MODE/SHIFT INDICATOR CIRCUIT
TROUBLESHOOTING ··············································· 12-95
MODEL IDENTIFICATION············································· 1-3
MUD GUARD ······························································· 2-11
N
NEUTRAL DIODE (NC700X/XA/S/SA) ························ 6-12
NEUTRAL SWITCH···················································· 22-27
NUTS, BOLTS, FASTENERS ······································ 3-29
O
O2 SENSOR ································································· 4-69
OIL PRESSURE INSPECTION······································ 9-6
OIL PUMP (NC700X/XA/S/SA) ······································ 9-6
OIL PUMP (NC700XD/SD)············································· 9-8
OIL STRAINER····························································· 9-11
P
PARKING BRAKE CALIPER (NC700XD/SD) ············ 19-32
PARKING BRAKE INDICATOR/SWITCH
(NC700XD/SD)··························································· 22-22
PARKING BRAKE LEVER (NC700XD/SD)················ 19-38
PCV············································································ 20-28
PGM-FI CONNECTOR LOCATIONS····························· 4-8
PGM-FI SYMPTOM TROUBLESHOOTING··················· 4-7
PGM-FI SYSTEM DIAGRAM ········································· 4-4
PGM-FI SYSTEM LOCATION········································ 4-2
PGM-FI TROUBLESHOOTING INFORMATION·········· 4-11
PILLION SEAT ······························································· 2-7
PISTON/CYLINDER··················································· 15-14
POSITION LIGHT························································· 22-7
PRIMARY DRIVE GEAR/CKP SENSOR ROTOR
CLUTCH/GEARSHIFT LINKAGE
(NC700X/XA/S/SA)················································ 11-15
DUAL CLUTCH TRANSMISSION (DCT)
(NC700XD/SD) ···················································· 12-108
R
RADIATOR····································································· 8-9
RADIATOR COOLANT················································· 3-15
RADIATOR RESERVE TANK······································ 8-14
REAR BRAKE CALIPER············································ 19-30
REAR FENDER A ························································ 2-12
REAR FENDER B ························································ 2-12
REAR FENDER MUD GUARD (U type)······················· 2-10
REAR MASTER CYLINDER·······································19-23
REAR WHEEL ······························································18-6
REGULATOR/RECTIFIER············································21-8
RIGHT CRANKCASE COVER
CLUTCH/GEARSHIFT LINKAGE
(NC700X/XA/S/SA) ··················································11-5
DUAL CLUTCH TRANSMISSION (DCT)
(NC700XD/SD)·······················································12-97
RIGHT ENGINE SIDE COVER (NC700XD/SD) ···········2-30
ROCKER ARM······························································10-8
S
SEAT COWL···································································2-9
SENSOR UNIT POWER LINE INSPECTION···············4-17
SERVICE INFORMATION
ALTERNATOR/STARTER CLUTCH························13-4
ANTI-LOCK BRAKE SYSTEM (ABS)·······················20-4
BATTERY/CHARGING SYSTEM·····························21-3
CLUTCH/GEARSHIFT LINKAGE
(NC700X/XA/S/SA) ··················································11-3
COOLING SYSTEM···················································8-3
CRANKCASE/TRANSMISSION/BALANCER ··········14-4
CRANKSHAFT/PISTON/CYLINDER························15-3
CYLINDER HEAD/VALVES ·····································10-3
DUAL CLUTCH TRANSMISSION (DCT)
(NC700XD/SD)·························································12-3
ELECTRIC STARTER················································6-4
ENGINE REMOVAL/INSTALLATION ······················16-4
FRAME/BODY PANELS/EXHAUST SYSTEM···········2-6
FRONT WHEEL/SUSPENSION/STEERING ···········17-8
FUEL SYSTEM ··························································7-3
HYDRAULIC BRAKE ···············································19-5
IGNITION SYSTEM····················································5-4
IMMOBILIZER SYSTEM (HISS) ······························23-3
LIGHTS/METERS/SWITCHES ································22-3
LUBRICATION SYSTEM ···········································9-4
MAINTENANCE ·························································3-2
PGM-FI SYSTEM·······················································4-6
REAR WHEEL/SUSPENSION·································18-4
SERVICE RULES ···························································1-2
SHELTER/SIDE COVER (NC700S/SA/SD) ·················2-15
SHIFT CONTROL MOTOR/REDUCTION GEARS···12-109
SHIFT INDICATOR TROUBLESHOOTING················12-61
SHIFT SPINDLE ANGLE SENSOR··························12-116
SHOCK ABSORBER ··················································18-14
SHOCK LINKAGE·······················································18-13
SHROUD/SIDE COVER (NC700X/XA/XD) ··················2-14
SIDE COWL (NC700S/SA/SD)·····································2-13
SIDESTAND ·································································3-27
SIDESTAND SWITCH ················································22-28
SINGLE SEAT ································································2-7
SPARK PLUG·································································3-8
SPECIFICATIONS··························································1-6
SPEEDOMETER/VS SENSOR ··································22-16
STARTER CLUTCH····················································13-10
STARTER MOTOR·························································6-8
STARTER RELAY (NC700XD/SD)·······························6-12
STARTER RELAY SWITCH ·········································6-10
STATOR ·····································································13-13
STEERI
NG HEAD BEARINGS·····································3-30
STEERING STEM·······················································17-33
SUSPENSION ······························································3-28
SWINGARM································································18-16
SYSTEM DIAGRAM
BATTERY/CHARGING SYSTEM·····························21-2
ELECTRIC STARTER················································6-3
IGNITION SYSTEM····················································5-3
IMMOBILIZER SYSTEM (HISS) ······························23-2
SYSTEM FLOW PATTERN············································8-2
SYSTEM LOCATION
BATTERY/CHARGING SYSTEM·····························21-2

Honda NC700 2012 Specifications

General

Engine Type	670cc liquid-cooled parallel-twin
Bore x Stroke	73.0mm x 80.0mm
Compression Ratio	10.7:1
Front Brake	Single 320mm disc with two-piston caliper
Rear Brake	Single 240mm disc with single-piston caliper
Fuel Capacity	3.7 gallons
Fuel System	PGM-FI
Transmission	6-speed
Front Suspension	41mm telescopic fork
Rear Suspension	Pro-Link single shock
Front Tire	120/70-17
Rear Tire	160/60-17
Wheelbase	60.6 inches
Curb Weight	472 pounds