Xerox WorkCentre 5225 Service Manual

February, 2008
6-1
WorkCentre 5225, 5230
General Procedures
Launch Version
6 General Procedures and Information
How to use UI Diagnostics
UI Diagnostic Mode......................................................................................................... 6-3
Various Reports
Jam Report......................................................................................................................6-5
Failure Report ................................................................................................................. 6-5
Shutdown Report ............................................................................................................ 6-6
Diagnostics (NVM)
NVM Read/Write............................................................................................................. 6-7
IOT NVM List................................................................................................................... 6-8
IIT NVM List ....................................................................................................................6-31
Controller & Fax NVM List............................................................................................... 6-43
Diagnostics (Others)
Serial Number/Billing Meter Data.................................................................................... 6-113
Reading HFSI.................................................................................................................. 6-114
Initialize HFSI Counters .................................................................................................. 6-115
Adjust Tone Up / Down ................................................................................................... 6-119
Tray5 (Bypass) Guide Adjustment .................................................................................. 6-120
Initialize NVM .................................................................................................................. 6-121
Component Control......................................................................................................... 6-123
Hard Disk Diagnostic Program........................................................................................ 6-134
Test Pattern Print ............................................................................................................ 6-135
Webpage Administrator Password.................................................................................. 6-137
Center Tray Offsetting..................................................................................................... 6-138
E-Mail Icon ...................................................................................................................... 6-138
FAX Output Separation................................................................................................... 6-139
General Procedures
GP 1 Intermittent Problem RAP...................................................................................... 6-141
GP 2 Fax Diagnostics ..................................................................................................... 6-142
GP 3 Resetting the Administrator Password................................................................... 6-144
GP 4 Replacing Billing PWBs ......................................................................................... 6-145
GP 5 Printing Reports ..................................................................................................... 6-146
GP 6 Special Boot Modes............................................................................................... 6-147
GP 7 Country Code Setting............................................................................................. 6-148
GP 8 Firmware Version................................................................................................... 6-149
GP 9 Key Operator Log In............................................................................................... 6-150
General Information
Space Requirements....................................................................................................... 6-151
Product Specs................................................................................................................. 6-152
Common Tools................................................................................................................ 6-154
Product Tools and Test Patterns..................................................................................... 6-155
Log Book Storage ........................................................................................................... 6-155
Cleaning Materials .......................................................................................................... 6-156
Machine Consumables.................................................................................................... 6-156
Glossary of Terms........................................................................................................... 6-157
Change Tag Information
Change Tag Introduction................................................................................................. 6-159
IOT/Processor (P) Tags .................................................................................................. 6-159

Xerox WorkCentre 5225 Specifications

General

Maximum print size	A3 (297 x 420 mm)
Internal memory	No MB
Type	Digital copier